Champion Power Equipment 41311 Manual do Proprietário

41311 Rev 41311-20100311 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China 7000 Peak Watts / 6000 Running Watts PORTABLE GEN

Controls and Features 6 Rev 41311-20100311 E Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself w

Controls and Features Rev 41311-20100311 E 7 Power Panel (1) Ignition Switch – Turn the ignition key to the “On” position to start the generat

Controls and Features 8 Parts Included Your Model 41311 Gasoline Powered Generator ships with the following parts: Wheel Kit Axle 1 piece 10” Solid

Assembly Rev 41311-20100311 E 9 Assembly Your generator requires some assembly. This unit ships from our factory without oil. It must be properly

Assembly 10 Rev 41311-20100311 E Install the Spark Arrester Insert the spark arrester screen into the muffler outlet. Secure the spark arrester by

Assembly Rev 41311-20100311 E 11 CAUTION Use regular unleaded gasoline with a minimum octane rating of 85. DO NOT mix oil and gasoline. Fill tan

Operation 12 Rev 41311-20100311 E Operation Generator Location Please consult your local authority. In some areas, generators must be registered wi

Operation Rev 41311-20100311 E 13 NOTE Connecting a generator to your electric utility company’s power lines or to another power source may be a

Operation 14 Rev 41311-20100311 E Wattage Reference Chart Use the chart to determine approximate wattage requirements for your equipment. NOTE S

Maintenance Rev 41311-20100311 E 15 Maintenance The owner/operator is responsible for all periodic maintenance. NOTICE Maintenance, replacement,

Maintenance 16 Rev 41311-20100311 E Spark Arrester 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the two

Storage Rev 41311-20100311 E 17 Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. Fo

Specifications 18 Rev 41311-20100311 E Specifications Engine Specifications Engine 389 cc OHV CPE Electric Start Generator Specifications Running

Specifications Rev 41311-20100311 E 19 Parts Diagram

Specifications 20 Rev 41311-20100311 E Parts List Item Part Number Description Qty 1 ST05FD-05032400 Control Panel 1 2 ST02FD-05702005 Switc

Specifications Rev 41311-20100311 E 21 Item Part Number Description Qty 52 ST188FD-1731000A Muffler 1 53 ST188FD-1732200-A Muffler Outer Pr

Specifications 22 Rev 41311-20100311 E Item Part Number Description Qty 106 GB5789-FB8-25 Flange Bolt M8×25 2 107 ST188FD-1743002-C Vibratio

Specifications Rev 41311-20100311 E 23 Wiring Diagram

Troubleshooting 24 Rev 41311-20100311 E Troubleshooting Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug Re

Warranty Rev 41311-20100311 E 25 Warranty CHAMPION POWER EQUIPMENT 1 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warr

Table of Contents Introduction ... 1Portable Power Generator ... 1Accessories ...

Warranty 26 Rev 41311-20100311 E Champion Power Equipment, Inc (CPE), and the United States Environment Protection Agency (U.S. EPA.) Emission Cont

Warranty Rev 41311-20100311 E 27 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System

Warranty 28 Rev 41311-20100311 E ECS Warranty claim. CPE shall not be liable hereunder for failures of any warranted parts of a CPE engine caused

Notes Rev 41311-20100311 E 29 Notes

Introduction Rev 41311-20100311 E 1 Introduction Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds

Manual Conventions 2 Rev 41311-20100311 E Manual Conventions This manual uses the following symbols to help differentiate between different kinds o

Safety Rules Rev 41311-20100311 E 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instr

Safety Rules 4 Rev 41311-20100311 E WARNING Running engines produce heat. Severe burns can occur on contact. Combustible material can catch fire

Safety Rules Rev 41311-20100311 E 5 CAUTION Improper treatment or use of the generator can damage it, shorten its life and void your warrant