Champion-power-equipment 90720 Manual do Utilizador descarregar pdf (Página 26)

23 REV 90720-20131010

ENGLISH 90720

TROUBLESHOOTING

For further technical support:

Technical Service

Mon – Fri 8:30 AM – 5:00 PM (PST/PDT)

Toll Free: 1-877-338-0999

tech@championpowerequipment.com

Problem Cause Solution

Engine will not start No fuel Add fuel

Faulty spark plug Replace spark plug

Unit loaded during startup Remove load from unit

Engine will not start;

Engine starts but runs roughly

Low oil level Fill crankcase to the proper level

Place log splitter on a ﬂat, level surface

Choke in the wrong position Adjust choke

Spark plug wire loose Attach wire to spark plug

Engine shuts down during operation Out of fuel Fill fuel tank

Low oil level Fill crankcase to the proper level

Place log splitter on a ﬂat, level

surface

Engine cannot supply enough power or

overheating

Insufﬁcient ventilation Check for air restriction. Move to a

well ventilated area

Wedge movement is slow or erratic Air in the hydraulic oil system Purge air by extending and retracting

the wedge several times until motion

is smooth

Debris lodged in beam guides Clear debris from beam

Low hydraulic oil Check oil level and add as needed

Oil leak from hose connection Loose hose clamp or hydraulic ﬁtting Tighten hose clamp or hydraulic ﬁtting

Oil leak from cylinder Faulty cylinder rod seal Contact Customer Service

Scored or bent cylinder rod Contact Customer Service

Loose hydraulic ﬁtting Tighten hydraulic ﬁtting

Faulty combination washer seal on

cylinder hydraulic ﬁtting

Contact Customer Service

Wedge will not extend or retract Faulty control valve Contact Customer Service

Faulty hydraulic pump Contact Customer Service

Low hydraulic oil Check oil level and add as needed

Wedge does not Auto-Return Low hydraulic oil Check oil level and add as needed

Faulty control valve Contact Customer Service

Excessive bouncing while towing Under-inﬂated tires Inﬂate tires to proper pressure. Refer

to tire sidewall

1 2 ... 21 22 23 24 25 26 27 28 29 30

Comentários a estes Manuais

Sem comentários

Champion-power-equipment 90720 Manual do Utilizador Página 26

Comentários a estes Manuais